Sega Saturn

llfliA" SERVICE MANUAL SEGA SATURN (PAL) NO.

013- 1

ISSUED

JUNE, 1995

CONTENTS 1. SPECIFICATIONS · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 3 2. IDENTIFYING PARTS · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 4 3. ACCESSORIES· · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 5 4. IDENTIFICATIONS AND LOCATIONS OF CIRCUIT BOARDS · · · · 5 5. DISASSEMBLY PROCEDURE································· 6 6. CD DRIVE MAINTENANCE AND ADJUSTMENT· · · · · · · · · · · · · · · · 8 7. BLOCK DIAGRAM · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 11 8. SCHEMATIC DIAGRAMS · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 13 9. CIRCUIT BOARD DIAGRAMS · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 27 10. PARTS SPECIFICATIONS .. ··· .. · .. · .. ··· .... ····· .. ···· .. · .. 32 11. EXPLODED VIEW & PARTS LIST · .. · · .. · · ...... · .. · ...... · .. 70 11-1. Exploded View··········································· 70 11-2. Mechanical Parts List · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 71 11-3. Electrical Parts List · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 72 11-4. Accessories/Package list · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 77

Sega Enterprises, Ltd.

PROTECTION OF EYES FROM LASER BEAM DURING SERVICING This set employs laser. Therefore, be sure to follow carefully the instructions below when servicing. Warning When servicing, do not approach the laser exit with the eye too closely. In case it is necessary to confirm laser beam emission. Be sure to observe from a distance of more than 30 em from the surface of the objective lens on the optical pick-up block.

£

Cautio"' Invisible laser radiation when open and interlocks defeated avoid exposure to beam

Caution Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.

This console is classified as a CLASS 1 LASER product.

SAFETY PRECAUTIONS Notice: Comply with all cautions and safety related notes located on or inside the cabinet and on the chassis. I. When replacing a chassis in the console, all the protective devices must be put back in place, such as barriers, non-metallic knobs, adjustment and compartment covers/shields, isolation resistors/capacitors, etc. ' When service is required, observe the original lead-dress. Extra precautions should be taken to assure correct lead dress in the high voltage circuit. 3. Always use the manufacturer's replacement components. Especially critical components as indicated on the circuit diagram should not be replaced by other manufacturer's. Furthermore, where a short-circuit has occurred, replace those components that indicate evidence of overheating. PRODUCT SAFETY NOTICE Many electrical and mechanical parts have special safety-related characteristics. These are often not evident from visual inspection nor can the protection afforded by them necessarily be obtained by using replacement components rated for higher voltage, wattage, etc. Replacement parts which have these special safety characteristics are identified in this Service Manual. Electrical components having such features are identified by marking with a it, in the parts list in this Service Manual. The use of a substitute replacement component which does not have the same safety characteristics as the SEGA recommended replacement one, shown in the parts list in this Se[Vice Manual, may create shock, fire, or other hazards. Product Safety is continuously under review and new instructions are issued from time to time. CAUTION ON FUSE REPLACEMENT Caution: For continued protection against risk of fire, replace only with same type, amperage, volt fuse. Attention: Afin d'assurer une protection permanente contre tout risque d'amon;age electrique, replacer uniquement par un fusible de meme type et de amperes volts.

8

.8.

This symbol indicates a Fast Operating Type Fuse.

This symbol indicates a Time Lag Type Fuse.

-2-

SATURN COMPATABILITY Audio CD: The normal audio Compact Disc is playable on the Saturn machine, and can be altered with all the effects of a modern Hi-fi and more. Surround sound, vocal cut-out for Karaoke, program sequence of tracks and shuffle to name but a few. You need no extra equipment to play music CDs on your Saturn.

CD+G: CD and Graphics are a format where simple visuals can appear on the screen that relate to the music. These visuals might include stills of the band, or other pictures. You need to buy no extra equipment to use CD+G on your Saturn.

CD+EG: CD and extended graphics is a new medium ready to be utilised by the music community. It is basically an enhanced version of what is described above in CD+G. You need no extra equipment to use CD+EG on your Saturn.

MPEG: MPEG is the standard industry format for compressing Full Motion Video footage. This means that the footage takes up less disk space, and when it is to be viewed, the MPEG program decodes the footage and plays it on screen. The MPEG add-on is needed in order to use the MPEG video CDs and Philips CDi. At the current rate of compression one movie can fit on two CDs. ',

I

Developed by Philips, CDi is an interactive CD format that can be used in a variety of educational and entertainment purposes. Using video footage and CD quality sound CDi has become an industry leader in the field of interactive fun._ The MPEG add-on is required to access the full range of CDi software

Kodak Photo CD: Photos stored on CD have theoretically infmite life, are always picture perfect and will never fade or be otherwise damaged. The Saturn can access Kodak Photo CDs with the use of another Saturn CD which allows the user to see display the photos in various ways. There are many Kodak Photo CD stores open in the major cities.

Frame Buffering: A technique to maximise graphic display performance by letting the graphics processor chip "set aside" images it has already calculated, allowing it to work on enerating the next fraction of a seconds visual images, all while the screen is still busy painting the last fraction of a second's display. Playfields: The background(s), anything that is on screen that it not a . sprite. When two playfields (layers of bacground) are contolled properly, parrallax scrolling can result.The Sega Saturn has a whole chip dedicated to controllingbackgrounds (the VDP2 or Video Display Processor 2") that can generate 5 distict layers of background at the same time. Polygons/Second: (1000's of) The number of polygons of a given size that can be drawn on the screen in one second. This figure does not include the size of the polygons, nor their texturing, shading, or lighting.

Realtime: An important adjective that usually indicates the game display is being re-calculated every second, taking into account the full effects of the player's actions. When reffering to a game's response or speed, it means the game responds instantly to the player's commands.

Render: Drawing 3D graphical objects on a computer or game machine. "BUG" and "Clockwork Knight" are filled with beautifully rendered characters.

Texture Mapping: Copying a bit-map onto the faces of selected polygons to give the illusion of surface texture. "Daytona USA" is a great example of a texture mapped game.

Wireframe: A connect the dots approach to showing graphical objects by drawing lines between sets of points that make up a geometric outline. Dynamic Perspective: Constantly changing the point of view ("camera angle") so that the players feel that they are weaving in and around the on-screen action. Typically requires strong scaling and rotational capabilities. This can be seen on Sega Sports games on Saturn.

1. SPECIFICATIONS Ratings MK - 80200-50

Model

Power supply

AC220-240 V 50/60 Hz

Power consumption

Approx. 20W

Operating environment Dimensions

Temperature 5 °C to 35 °C HumiditylO% to 80% RH (no condensation) 260 mm(W) X 230 mm(L) X 83 mm(H) (10.2 inches) x (9.0 inches) x (3.2 inches)

Specifications CPU

Memories

Graphics

Master

32bit RISC SH2 (28.4 MHz, 25MIPS)

Slave

32bit RISC SH2 (28.4 MHz, 25MIPS)

Sound

68ECOOO (11.3 MHz)

Work RAM

16 Mbit

Video RAM

12 Mbit

Sound RAM

4Mbit

CD Buffer RAM

4Mbit

IPLROM

4Mbit

Backup RAM

256 Kbit

Resolution Colors Sprite

320 x 224 dot etc. 1024/2048 (16,770,000 simultaneous transmission) Enlargement, Reducation, Rotation, Transformation

5 screen maximum

Scroll

XY Scroll

4

Rotation

2

Enlargement I reduction

2

Windo~

2 Vertical cell scroll

Special features

Lateral line scroll Enlargement I reduction Specialized hardware

Polygons CG Functions

Wire frame Special features

Flat shading Gouraud shading 32 channels 16 bit sampling Sampling rate 44.1 kHz max. AudioDSP

Sound

PCM & FM sound source

CD-ROM

Intelligent double-speed CD drive

[Note] Characteristics and specifications may be changed without notice.

-3-

2. IDENTIFYING PARTS 2-1. Front View of Console

OPEN Button

2-3. Control pad

Cartridge Slot

RIGHT SHIFT Button

A Button B Button C Button

ACCESS Light DIRECTIONAL Button CONTROL PORT 1

START Button

CONTROL PORT 2

2-2. Back View of Console

2

POWER Jack

Master Reset Switch

AN OUT Jack

-4-

3. ACCESSORIES

Positive Side

B RGB Cable

Lithium Battery (CR2032)

AC Cable [UK]

AC Cable [SOE]

AC Cable [AUSTRALIA]

4. IDENTIFICATIONS AND LOCATIONS OF CIRCUIT BOARDS

CD Drive Unit

P. SW Board

Main Board

R. SW Board

Fig. 4-1

-5-

5. DISASSEMBLY PROCEDURE 5-1. Top Case Removal

5·3. CD Drive Unit Removal

1) Remove six screws ® and then the top case in the direction of the arrow.

1). Disconnect two connectors and one flat cable. 2) Remove the CD drive unit in the direction of arrow

©.

Fig. 5-1

5-2. CD Compartment lid Removal 1) Remove two screws ® and then the bracket lid CD

Fig. 5-3

5-4. SH-1 Board Removal l) Remove four screws ® and then the top shield plate. 2) Remove screw CD and release three tabs, then lift the SH-1 board in the direction of arrow Q) to remove it.

spring. 2) Remove spring © . 3) Remove two screws@ and then the oil dumper. 4) Push the lever in the direction of arrow ® to release the boss and then push the lever in the direction of arrow ® to remove the CD compartment lid.

Fig. 5-4

Fig. 5-2

-6-

5-5. Main Board Removal 1) Remove four screws unit supports. 2) Remove five screws

®

holding the CD drive

©

and then the main board.

Fig. 5-5

5·6. Power, Power Indicator and R. SW Boards Removal I) Remove three screws If@ and then the power board. 2) Remove screw ® and then the power indicator board. 3) Remove two screws @ and then the R. SW board.

R.SWBoard

Fig. 5-6

-7-

6. CD DRIVE MAINTENANCE AND ADJUSTMENT 6-1. Maintenance of Pickup I) Checking the laser diode As the laser diode wears out, the RF level (amplitude of eye pattern) becomes lower. Check that the RF level is 0.8V - l.4Vp-p during maintenance. If the RF level is less that 0.8Vp-p then the pickup should be replaced.

6-2. Laser Pickup Replacement Procedure Turn the power switch off and unplug the power cord from the AC outlet.

1 Replace the pickup.

1

2) Variable resistor on the APC board The variable resistor attached to the pickup on the APC board is used to adjust the output power of the laser. This adjustment is done at the facto!}' and can not be performed in the field. If the laser's output power is low, the laser diode has worn out and should be replaced. Adjusting this variable resistor may cause damage to the laser diode.

Set the door close detection switch to on manually and turn the power switch on. Check that the laser emits light for approx. 3 seconds and the pickup lens moves up and down.

[Note] Be careful not to bring your eyes too near to the laser and do not look straight at it as this is dangerous.

l Check the FE bias.

I Adjust the focus gain.

1 Adjust the TE balance.

l Adjust the tracking gain.

I f Check that the eye pattern waveform can be observed at the RF test point. (0.8-1.4Vp-p)

I

i

Replacement complete

[Note] Since the adjutments influence each other, it may be necessal}' to repeat them 2 to 3 times. times.

-8-

6-4-1. FE (Focus Error) bias adjustment and focus gain adjustment

Adjustment Preparation Apply markings to the positions of the variable resistors before adjustment. If the adjustment are out of the specifidtions, the following symptoms may occur.

I. Connect the oscilloscope to test point FE IN as shown in Fig. 6-2. 2. Turn the power switch on and set the CD drive to

[Focus gain]

the stop mode. 3. Adjust Rll4 (FE bios) so the DC voltage at the test point (FE IN) is OV. 4. Play the first track of the test CD and adjust Rill (Focus gain) so the DC voltage is - 7mV.

If the focus adjustment is too low the pickup lens will not be able to focus properly and the disk will not rotate. If the adjustment is too high portions of a track may be skipped and noise will increase.

[Tracking gain] If the tracking adjustment is too low the drive is more susceptable to shocks or bumps, portions of a track may be skipped or the disk time counter may stop. If the adjustment is too high the pickup lens may oscillate leading to unstable or distorted sound. The focus and tracking adjustments are done so as to mutually satisfy conflicting characteristics.

6-4-2. FE balance and tracking gain adjustments I. Connect the oscilloscope to test point BP IN as shown in Fig. 6-3. 2. Turn the power switch on and play the first track of the test CD. 3. After play has begun, connect the TEST pin to

6-3. Test equipment and tools necessary for adjustment

GND. 4. Adjust RI04 (FE balance) so the center voltage

I. Oscilloscope 2. DC voltmeter 3. Non-metallic adjustment screwdriver 4. Test CD (A-BEC TCD-792A)

of the waveform is OV. 5. Adjust Rll3 (tracking gain) so the amplitude of the wavefonn is 0.4V as in Fig. 6-4.

6-4. CD Drive Unit Adjustment Procedure 10k Q

r--------------------------,

:,

:,

0

FEIN

' ' 'I '''

IW

I

: _ _B $ _ _ _ _ _ _ r_ _ ~--

vc

Fig. 6-2

!

10k Q

!\

IC201

Fig. 6-4

€> 401C

Oscilloscope

BPI.._

'I

'' ''' I' I 'I 'I '' '' ' '

:'

''

Fig. 6-3 r-----------------'

'

'-------------------------------------------------------··--------------------------------------R104 R111 R113 R118 R114

t:rn

~

L@] IBPij

I F. OFFI

FE IN.

GND

Fig. 6-1

-9-

-10-

7. BLOCK DIAGRAM

.-----------------· 1 MPEG 1

fCtRTRI DGE CONNECTOR CNl

L

_t

POWER SUPPLY BOARD

..__ CLOCK!

14

2

__,

~ J,I 1 ~t~l

(Ng~o8~~Dl

/'1/

NTs/ / / DOTSEL EXTCLK

·28. 6MHz 32bit RISC CPU ·4Kbyte CACHE • INTERNAL MATH PROCESSOR •32bit INTERNAL/EXTERNAL

3

SHI ~ BOARD CONNECTOR

scu

OCU IC301

lJ

_ 1----.

I

1 _

---..

~

SHl IC!OI

BUFFER RAM I CI02 4Mb it

\

1+----------\\--L__----f---+--_j

1

~

l ----

....-~--..

I

n

[2_0--

~:1 I I I I

I I I I I

~~~~ 3

I I

I

I

I- UP TO 72 Ml NUTES (30 FRAMES PER SECONDl POSSIBLE ON ONE co.

MPEG I I BOARD I l 91.98 115. 121. ll4. 141 I vee I I

I I I I

I G!IJ,6. !Ua 26. 3l 42. 50. 56. 69. 78. 86. I 91.98. liS. 121. 134. 141 I vee I

I I I I

.G;:fa.,.

: I

1_r.: C72 1 I ~;

I

I

: : I

I I

J:C69

T~'·

J:C6

CE4 I•

TD.I• 1

CD

r-----------------,

I VCC ,9. 21. 31 . 41. 55. 69. 79. 94. lOS. 117. 121. 139. 149. !60. !Ia 184. 193. 208 1

CE2 ,.

AA8US

'-...;...:,..:>....:>...::.....::.....::..._:,_..:...._________.:.___~882 ABUSC(JfrnQ I 8YPA1S CAPACITOR F-'88=--.....

vee vee vcco VCCQ vcco

©

MIREO ~ MIRQ

1'--:C"'Ol"'l:---il"iiS'-f COl 1 I'--:C~O;0

~

rfr

@(~!

CNlD

55111111 lll:llll

A

-----w~~[j

c

8

-23-

0

E

F

G

-24-

H

•

BO~RD

I

LBI~

I

~

CN14

--

~

2

,-

_

t

~J

IJ()

J3396

...!!.

@

LDl~ ·

LBIOIEBI

IIC9

Cl24 IIDI'r

...!!.

• a.t3

a.t2

Rl48

8-7. Schematic Dlagram-7 [SH-1 C.B] RIIO 4 1K

TPJ

r-----~--------------------------------------------~~~_,--~

com

l

52610 RESET GNJ COAT A tllATA

l

CQIIEQ

2 3 4 5

COtiU

6

CIJIISOC

7 8 9 10 II 12 ll 14 15 16 17 18 19 20

GNJ liCK

GNJ DAS CKX II'X GNJ C2F SII'X SCKX SOAS GNJ ACCESS

TP4 9

~-

=

. -- - - - - -NITe125 USED

l

N-

r------------:;..--t-+------;.

RIOl 4. 71(

0

f"N\'1

ClltSYt«:

ttt514260

~ DO

Dl 02 1-==----t DJ SIJt4 1 vee

~

41K

----m ----m DIS

e12l ~01

1

CXX

II'X

~SlitS SIJt6

II 12

RI02 IOK

SII'X SCXX SDAS

liAS

:!15

~

l6

l34nr JJ l2 ll

08 t«:

t«: t«:

S11iB

J0

~:~

~A8 26~

Ws t«:

Al A6 IS M

25 24 23 22

+-----1f+-~204Lv-ec_ _ _v_ss_.~

T rJr

Cl20

I

'"

S1Jt6 SDt7

~

~

Sllill SlliiO Slllt9

ffiS 29

10 ~ II ).#..-4 12 ~~ 3

1m-

Sllil4 511113 Sllil2

~55 12 35

011 010 D9

~

~ ~

vee

----m-C2F

B 9

l6 J7

DIS Dl4 DIJ

~

RI06

SRD 519 SA8 Sl7 SA6 SIS

I~

~~~t;;~~::lli!l!ll!!l!~~gii::lli!ll!8~::l~~;:;~~g ~ > > >~~~~~~~~

IML - 2'{-1 TI!Qii

m+ ~~

~:;;

'2

I!!

vss

SDt9

vee

~J

'" " 14

>---+.=.------Tisi-1 _ I SDtiD 16 ~~~rT SDtll 17 fh18 ; ; 14 ~

~11 23

SIJtiS SAO SAl Sl2 Sl3 SA4 SIS

21 22

mij24 25 26 27 28

~

~ DIO

IC101

Rill'! 2.21:

78

XlOl

vss

2tntz

7l

72

lifm

etol:!: lOP

l

~~ ~ 69 lllEOI

=

tll64J7097

IJlEQI

Oil 012 DIJ

68 67

Dl4 DIS VSS

!lOCAl

2

L6~4---t--+--::----t-----H----------------,

rRifWT t-'6;i;J- -"Atv-+-- -t--Q

~

:~

VSS

62

m

RD lo1lH

IoRI.

57

vee

1 T

59

i.iiH 58

R!j

I~

Rill

1-4.-: 01 NI~T USED r,!(

~ 160

l2 A3 "" AS

O~

~~41

DACKI lllEOO DACKO

~ ~

••••••••••••••••••••~~~-~-~•

Nl~~~r

n:

X~~~ ~ EXTAl

-o,....~a:~o-~~~~~~~~~tl~e:~N u ~~~~~~:::l~o

0. 01

NITUSED

~~ I ~75~

D6 07 VSS 08

~

till~

~rn--m

6 02 7 OJ

~

0. 01

t02

5

10 II

VCC

vee ~ vee !-*-82

vee

Rl04 !OK

~ ~ ~ § ~ :: ~ ~ ~~;:::.IS! o: ~ ~l:g :o .: "'1£~ 1----t-...,blr--l,o-6-~f.-e- -' 0

-' 0

MEMORY ARRAY BANK1

512

X

256

X

16 bit

(.)

If)

CONTROL LOGIC & TIMTING GENERATOR

-36-

ICS

SCU {Custom Gate Array)

IC CUSTOM CHIP SCU QFP

Pans No.: 315-5688

•Top View

• Block Diagram 157 156

INT

I I

f--

'---z:-----1~ CPU

A-Bus

1/F

105

52

1/F

DMA

104

53

TIMER

-

.__ :: -

1-_:-+---ilB B-Bus

1/F

DSP

• Description No.

1/0

Name

I 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

-

I/0

VSS AD4 ADS· AD6 AD7 AD8 AD9 ADIO VDD ADII

-

vss

I/0 I/0 1!0 1/0 0 0 0

AD12 AD13 AD14 ADIS AAO AAl AA2

1!0 1/0 1/0 1/0 I/0 I/0 1!0

-

-

vss

0

AA3 VDD AA4

21

-

22

0

Function GND A-bus data bit 4 A-bus data bit 5 A-bus data bit 6 A-bus data bit 7 A-bus data bit 8 A-bus data bit 9 A-bus data bit 10 Power supply +5V A-bus data bitll GND A-bus data bit 12 A-bus data bit 13 A-bus data bit 14 A-bus data bit 15 A-bus address bit 0 A-bus address bit 1 A-bus address bit 2 GND A-bus address bit 3 Power supply +5V A-bus address bit 4

-37-

No.

1/0

Pin Name

23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43

0 0 0 0

AA5 AA6 AA7 AA8 VSS AA9 AAIO AAll VDD AA12 AA13 AA14

-

0 0 0

0 0 0

vss AA15 AA16 AA17 AA18 AA19 VDD AA20

0

-

0 0 0 0 0 0 0 0

44

45 46 47 48 49

so 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84

0 0 0 0 0

'

vss

1/0

AA21 AA22 AA23 AA24 AFCO AFCI AAS ACSO VSS ACSI ACS2 VDD AWAIT All:«) TEST ARD AWRU AWRL VSS ATIMO ATIM I ATIM2 BDO BDl BD2 VDD BD3 VSS BD4 BD5 BD6 BD7 BD8 BD9 BDlO VDD BOll

I/0 1/0 I/0

BD12 BD13 BD14

0 0

I I I 0 0 0

0 0 0 1/0 1/0 1/0

1/0

-

1/0 1/0 1/0 1/0 1/0 I/0 1/0

-

vss

Function A-bus address bit 5 A-bus address bit 6 A-bus address bit 7 A-bus address bit 8 GND A-bus address bit 9 A-bus address bit 10 A-bus address bit 11 Power supply +5V A-bus address bit 12 A-bus address bit 13 A-bus address bit 14 GND A-bus address bit 15 A-bus address bit 16 A-bus address bit 17 A-bus address bit 18 A-bus address bit 19 Power supply +5V A-bus address bit 20 GND A-bus address bit 21 A-bus address bit 22 A-bus address bit 23 A-bus address bit 24 A-bus function code bit 0 A-bus function code bit 1 A-bus address strobe A-bus chip select 0 GND A-bus chip select 1 A-bus chip select 2 Power supply +5V A-bus external wait A-bus external interrupt factor Test mode selection (normally, input "H") A-bus read pulse A-bus byte 0 (AD15-8) write pulse A-bus byte 1 (AD7-0) write pulse GND A-bus external access timing 0 A-bus external access timing 1 A-bus external access timing 2 B-bus address/data bit 0 B-bus address/data bit 1 B-bus address/data bit 2 Power supply +5V B-bus address/data bit 3 GND B-bus address/data bit 4 B-bus address/data bit 5 B-bus address/data bit 6 B-bus address/data bit 7 B-bus address/data bit 8 B-bus address/data bit 9 B-bus address/data bit 10 Power supply +5V B-bus address/data bit 11 GND B-bus address/data bit 12 B-bus address/data bit 13 B-bus address/data bit 14

-38-

No. 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 Ill 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146

I I

'

1/0

Pin Name

I/0 I I I I 0 0

BOIS IROL IRQV IRQH BRDY2 BCS2 BADDT VSS BDTEN VDD BCSS BRDYS IRQS BCSI BRDY1 IR1)1 CAD CAl CA2

-

0

0 I I 0 I I 1/0 1/0 1/0 -

I/0 1/0 1/0 1/0

1/0 1/0 1/0 1/0

1/0

1/0 1/0 1/0

vss VDD CA3 CA4 CAS CA6 VSS CA7 CAS CA9 CAlO VSS CAll VDD CA12 CA13 CA14

-

vss

I/0 I/0 I/0 I/0 I/0

CA15 CA16 CA17 CA18 CA19 VDD CA20·

-

l/0

1/0 1/0 l/0 1/0 1!0 l/0 1/0

1/0

1/0 1/0 I/0 1/0

vss CA21 CA22 CA23 CA24

coo CDl CD2 VSS CD3 VDD CD4 CDS CD6 CD7

-

vss

1/0 1/0

CDS CD9

Functior:. B-bus address/data bit 15 Light pen interrupt VDP2•V blank interrupt VDP2•H blank interrupt VDP2 data ready VDP2 chip select · B-bus address/data switching signal GND B-bus data enable +SV Power supply SCSP chip select SCSP data ready SCSP interrupt VDPI chip select VDPI data ready VDPI interrupt C-bus address bit 0 C-bus address bit 1 C-bus address bit 2 GND +SV Power supply C-bus address bit 3 C-bus address bit 4 C-bus address bit 5 C-bus address bit 6 GND C-bus address bit 7 C-bus address bit 8 C-bus address bit 9 C-bus address bit 10 GND C-bus address bit 11 +SV Power supply C-bus address bit 12 C-bus address bit 13 C-bus address bit 14 GND C-bus address bit 15 C-bus address bit 16 C-bus address bit 17 C-bus address bit 18 C-bus address bit 19 +SV Power supply C-bus address bit 20 GND C-bus address bit 21 C-bus address bit 22 C-bus address bit 23 C-bus address bit 24 C-bus data bit 0 C-bus data bit 1 C-bus data bit 2 GND C-bus data bit 3 +SV Power supply C-bus data bit 4 C-bus data bit 5 C-bus data bit 6 C-bus data bit 7 GND C-bus data bit 8 C-bus data bit 9

-39-

No.

1/0

P.in"Name

147 148 149 ISO 151 152 153 154 155 !56 157 !58 !59 160 161 162 163 164 165 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 204 205 206 207 208

1/0 1/0

COlO COil VOO CDI2 VSS CDI3 CDI4 CDIS C016 CDI7

1/0 -

1/0

1!0 1/0 1/0 1/0

-

vss

1/0

CDI8 CDI9 VOO C020 C02! C022 VSS CD23 C024 CD25 CD26 CD27 VOO CD28 VSS CD29 CD30 CD31 CCSI CCS2 CCS3 VSS RESET CLK28 CRDWR CRO VDO CDQMUU CDQMUL CDQMLU C:DQMLL VSS RAS CAS CWAIT VDO CIVECF CIRLO CIRLI CIRL2 CIRL3 VSS CBREO CBACK MIREQ AA25 ADO AD! AD2 AD3 VDO

1!0 1/0 1/0 1/0

1!0 1!0 1/0 1/0

1!0 1/0

1!0 I/0 1/0 I I 0

I I 1/0 I

1!0

IJO I/0 I/0

0 0 0

I

0 0 0 0

0 I I 0 I/0 l/0 I/0 1!0

-

Function

·-

C-bus data bit I 0 C-bus data bit 11 +5V Power supply C-bus data bit 12 GNO C-bus data bit 13 C-bus data bit 14 C-bus data bit 15 C-bus data bit 16 C-bus data bit 17 GND C-bus data bit 18 C-bus data bit 19 +5V Power supply C-bus data bit 20 C-bus data bit 21 C-bus data bit 22 GND C-bus data bit 23 C-bus data bit 24 C-bus data bit 25 C-bus data bit 26 C-bus data bit 27 +5V Power supply C-bus data bit 28 GNO C-bus data bit 29 C-bus data bit 30 C-bus data bit 31 C-bus chip select 1 C-bus chip select 2 C-bus chip select 3 GND Initial reset System clock C-bus read/write C-bus read pulse +5V Power supply SDRAM byte 0 (CD31-24) write pulse SDRAM byte I (C023-I6) write pulse SDRAM byte 2 (CD! 5-8) write pulse SDRAM byte 3 (C07-0) write pulse GND SDRAMRAS SDRAMCAS C-bus external wait +5V Power supply C-bus interrupt vector fetch sycle C-bus external interrupt factor 0 C-bus external interrupt factor 1 C-bus external interrupt factor 2 C-bus external interrupt factor 3 GND C-bus right request C-bus right acknowiedge System manager interrupt A-bus address bit 25 A-bus data bit 0 A-bus data bit I A-bus data bit 2 A-bus data bit 3 +5V Power supply

-40-

IC6 DCC IC CUSTOM CHIP DCC QFP Parts No. : 315-5778

•Top View 51

80

50

81

I I

! I

100

31

30

•Pin Name No. I

2 3 4 5 6 7 8 9 10 II

12 13

14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29

1/0 I

I

0

TESTl TESTO BEN BDIR VSS DAO DAI DA2 DA3 DA4 DAS DA6 DA7 DA8

-

vss

-

VDD DRASO DRASl DRAS2 DRAS3 DUCAS DLCAS DWE DOE

0 0 0

0 I

Name

0 0 0 0 0 0 0

0 0 0 0 0 0 0 0

-

vss

-

VDD Al A2 A3 A4 A5 A6 A7 AS

I

I I

30

I

31 32 33

I

34

I

I I

No.

35 36 37 38 39

1/0

Name

50

I

51 52

I

A9 AlO All Al2 A13 VSS VDD A14 Al5 Al6 A17 Al8 A19 A20 A2l A22 A23 A24

53

-

vss

54 55

0 0

40 41

42 43 44

45 46 47 48 49

I

I I

I I

I I I I I

I I I I

56

-

57 58 59

I

I I

IREQl IREQ2 VDD IVECF RD/WR RD

60

-

vss

61 62 63

I I I

CS2 CSl

64

0

65 66 67 68

I

I

-41-

No.

69 70 71

0

72

0

73 74 75 76

0

I -

I

I

I I 0 0

I

I

I I I

0 0 0 0

WEO

vss

-

77

78 79 80 81 82 83 84 85 86 87 88 89

Name

1/0

I I

BACK EXBACK BRLS VSS BGR BREQ EXBREQ MFT1 SFTl VDD CK VSS RESET BS EWT IOCE EXTCEO EXTCEI EXTCE2

90

-

vss

-

WAIT VDD

91 92 93 94 95 96 97 98 99

0 0

VDD HINT VINT DECON ROMCE SMPCCE SRAMCE MOE MWR

vss

100

-

vss

cso

WTIN WEI

I

I I

0 0 0

IC7

IPL ROM

OS SATURN IPL-ROM PAL DIP

Parts No.: EPR-17933 Parts No.: MPR-17933

• Top View & Pin Layout AS AS

•Pin Name A0-Al7

A10

A11 A12 A13

A14 A15 A16 1

BY'i'E

Address inputs

CE

Chip enable

OE

Output enable Ground

GND BYTE DO-DIS

Data inputs/outputs

Vee

+SV power supply

GND D151A-1 07 014 06

010

03

013 05 012 D4

011

ICS

BACKUP RAM

IC CXK58267 AM-1 OL SOP

IC UPD43257B-1 OLL SOP

IC M5M5255BFP-12LL SOP

Parts No. : 315-0948-10

Parts No. : 315-0930-10

Parts No.: 315-0964-10

IC SRM20257LLM1 0 SOP

IC UM62257M-70LL SOP

Parts No. : 315-0965-10

Parts No.: 315-1002-70

II Block Diagram

II Top View & Pin Layout A14

A14

vee WE A13 AS AS A11 CE2

A13

A12

Vee

A11

MEMORY MATRIX 512 X 512

AS AS A7 AS

GND

AS

A 10

1

1101 1102 1/03 GND

o+++.f':5l5:t==f

CE1 IIOS 1/07 1106 1105

A4 A3

A2

I!OGATE COLUMN DECODER

• Description

A1

Name

AO

AO-Al4

CE1 o----or-...., CE20•---t

1101

1108

-42-

Function

Address inputs

1!01-I/08

Data inputs/outputs

CEl, CE2

Chip enable inputs

WE

Write enable input

Vee

+5V power supply

GND

Ground

IC9

SMPC

IC CUSTOM CHIP SMPC QFP

Parts No.: 315-5744

•Top View 52

64

I 51

I

19

33

20

32

• Description No.

1/0

Name

1

-

R70

2 3 4

1!0

R71 R72 R73

Function

No.

Not connected. Reset control

1/0

33

PIOOA

34

Pl01A

35

PI02A

36

I/0

PI03A

5

R50

37

PI04A

6

R51

38

PI OSA

7

I

8 9

10 11

12 13 14

R52

Jumper configuration input

R53

I!O

1!0

15

TEST OSCl OSC2 GND X2 XI RESET

vee

Not connected ~GND

39

PI06A

40

PIOOB

41

PIOlB

42

Clock 3

43

Ground Clock 4

PI03B

44

PI04B

45

PIOSB

46

PI06B

47

I

EXL

Input

Power

48

I

INTO/D13

Input Backup RAM reset control

17

I

cs

Chip select input

49

INT2!R01

18

I

R/W

Read/write input

50

DO

19

AI

51

20

A2

52

22 23

A3

l/0

-

D2 D4

AS

55

DS

24

A6

56

25

DBO

57

26

DBI

58

27

DB2

59

D9

28

DB3

60

DlO

29

l!O

DB4

Data bus

61

30

DBS

62

31

DB6

63

DB7

64

32

-43-

Reset control Not connected.

D3

53

Address bus

Dl

54

A4

Control pad

Master reset input

-

I/0

Control pad

PI02B I/0

16

21

Function

Name

1/0

D6 D7

Reset control

D8

1/0

-

R60 R61 R62 R63

Reset control Not connected.

IC10 VDP1 IC CUSTOM CHIP VDP1 QFP

IC CUSTOM CHIP VDP1 S QFP

Parts No. : 315-5689

Parts No. : 315-5883

•Top View 85

126

84

127 I I I I

43

42

• Description No.

1/0

Name

I 2 3 4 5 6 7 8 9 10

-

Ne VRAMA7 VRAMA8 VRAMA9 VSS veLK VUDQM VLDQM VSS veASN VRASN vee VWEN veSN MeLK RESETN vss esN ADN DTEN IRON READYN VBUSO VBUSl VBUS2 vss VBUS3 VBUS4 VBUS5 VBUS6 VRUS7 vee VBUS8 VBUS9 VBUSlO VBUSll vss VBUS12 VBUS13 VBUS14

11

12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40

0

0 0 0

0 0

0 0 I

-

0 0 0

-

0

0

0

'

Function Not connected. Address bus (VRAM) Ground for 1/0 pin Clock (VRAM) Upper byte input/output mask(VRAM) Lowerbyte input/output mask(VRAM) Ground for internal circuit Column address asserted (VRAM) Row address asserted (VRAM) Power supply Write enable (VRAM) Chip select (VRAM) Master clock Reset Ground for 1/0 pin Chip select Address/data select Data enable Interrupt request Ready Address/data bus (Syscon) Ground for 1!0 pin

Address/data bus (Syscon)

Power supply Address/data bus (Syscon) Ground for internal circuit Address/data bus (Syscon)

-44-

No. 4! 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 6! 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104

I

110

Name

!

0

VBUS15 NC NC FOAO FOAl FOA2 VSS FOA3 FOA4 FOAS FOA6

0

I

I

0 0 0 0

-

vee

0

FOA7 FOA8 FOA9 FOCSN

0 0 0 0 0 0

FOWEN FOCLK FRRASN FOCASN FOLDQM FOUDQM

0

-

-

vss

vss

Function Address/data bus (Syscon) Not connected. Address bus (FBO) Ground for 1/0 pin Address bus (FBO) Address bus Frame buffer (FBO) Address bus (FBO) Power supply Address bus (FBO) Chip select (FBO) Ground for internal circuit Write enable (FBO) Clock (FBO) Row address asserted (FBO) Column address asserted (FBO) Lower byte input/output mask (FBO) Upper byte input? output mask (FBO) Groun for 1/0 pin

FODO FODl FOD2 FOD3 FOD4

Data bus (FBO)

-

vss

Ground for internal circuit

0

FODS FOD6 FOD7 FOD8

Data bus (FBO)

-

vee

Power supply

0

FOD9 FODIO FODll FODI2

0

0 0

vss FOD13 FOD14 FOOlS NC NC FIDO FlDl F1D2

Data bus (FBO) Ground for I/0 pin Data bus (FBO) Not connected. Data bus (FBI)

-

vss

Ground for I/0 pin

0

FlD3 FID4 FIDS FID6

Data bus (FBI)

-

vee

Power supply

0

FID7 FID8 FlD9 FIDlO

-

vss

0

FIDll FID12 FID13 FlD14 FID15

Data bus (FBI) Ground for internal circuit

Data bus (FB 1)

-45-

No. 105 106 107 108 109 110 Ill 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165 166 167 168

1/0

N~me

-

VSS FICLK FICSN FIWEN FIRASN FICASN FlLDQM

0 0 0 0 0 0

0 0

-

vss

FIUDQM FIAO FlAl FIA2

vee

0 0 0

FIA3 FIA4 FlA5 FIA6 VSS FIA7 F1A8 FIA9

-

NC

0 0

-

-

-

0

HTIMN VTIMN V2CLK

-

vss

0 0 0 0

VOUTO VOUTI VOUT2 VOUT3

-

vee

0 0 0 0

VOUT4 VOUT5 VOUT6 VOUT7

-

vss

0 0 0 0 0

VRAMDO VRAMDI VRAMD2 VRAMD3 VRAMD4 VSS VRAMD5 VRAMD6 VRAMD7 VRAMD8 VRAMD9 VRAMDlO VSS VRAMD11 VRAMD12 VRAMD13 VRAMD14

0 0 0 0 0 0

0 0 0 0

-

vee

0 0 0 0 0 0 0 0

VRAMDI5 VRAMAO VRAMAI VRAMA2 VRAMA3 VRAMA4 VRAMA5 VRAMA6 NC

-

Function Ground for 1/0 pin Clock (FBI) Chip select (FBI) Write enable (FBI) Row address asserted (FBI) Column address asserted (FBI) Lower byte input/output mask (FB 1) Data bus (FB l) Lower byte input/output mask (FB 1) Address bus (FBI) Power supply Address bus (FBI) Address bus (FB 1) Ground for I/0 pin Address bus (BF1) Not connected. Horizontal sync timing Vertical sync timing Video clock (1!2 MCLK) Ground for 1/0 pin Display start address/video data Power supply Display start address/video output data Video output data Ground for internal circuit

VRAM data bus

Ground for 1!0 pin

VRAM data bus

Ground for internal circuit VRAM data bus Power suppiy VRAM data bus

VRAM address bus

Not connected.

-46-

IC12/13/15/16 IC UPD4502161G5-A12 TSOP NEC

IC HM5221605TT-17 TSOP HITACHI

IC LC382161T-17 TSOP SANYO

Parts No.: 315-0910-12

Parts No.: 315-1017-17

Parts No. :315-1012-17

• Top View & Pin Layout

•Pin Name A0-A9

Vss 0015 0014 Vss 0013 0012 Vee 0011 0010 1Vss 009 008

Vee 7 004 005

A3

Vee NC OOMU CLK CKE NC GNO 1 GNO A7 A6 AS A4

Vee

Vss

CAS 1

AS

Address inputs

DQO-DQ5

Data inputs/outputs

CLK

System clock input

CKE

Clock enable

cs

Chip select

RAS

Row address strobe command

CAS

Col/ address strobe command

WE

W ritre enable

DQML,DQMU Vee Vss.GND NC

DQ mask enable Supply voltage Ground No connection

• Description No.

1/0

Pin Name

l' 7, 13, 25, 38, 44, 50

-

vee

Power supply of internal circuits.

4, 10,26,41,47,50

-

vss

Ground pins.

l/0

DQ1-DQ16

2, 3, 5, 6, 8, 9, 11' 12, 39, 40, 42, 43, 45,46,48,49

Function

l/0 pins are the same as conventional DRAM.

14,36

I

DQML,DQMU

DQMU controls upper byte and DQML controls lower byte input/output buffers. In read mode, DQMU, DQML control output buffer impedance like conventional OE. If DQMU, DQML is high, output buffers become high impedance. If DQMU, DQML is low, output buffers become low imedance. If DQMU, DQML is low, output buffers become low impedance. And when device in write mode, DQMU, DQML control word mask. If DQMU, DQML is high input data is not written to memory cell. If DQMU, DQML is low input data is written to memory cell.

15, 16, 17

I

WECASRAS

WE CAS RAS have the same names with conventional DRAM. But these pins have different definitions with conventional ones. All of these pins only define command cycle definition. For detail information see command table.

18

I

cs

CS low start the command input cycle. When CS is high, all input are not referenced. But even if CS is high, internal operations i.e. bank active or burst are not changed.

19

I

A9

A9 is bank select signal (BS). In command cycle, A9=low select bank A and A9=high select bank B.

-47-

No.

1/0

Pin Name

Function

20,21-24,27-30

I

AO-A8

Row address (AX0-AX6, AX8) is detennined by A0-A8 level at the bank active command cycle CLK rising edge. (AX7 is don't care.) Column address (A YO-A Y7) is detennined by AO-A 7 level at read or write command cycle CLK rising edge. And this column address become bun;t access start address. A8 define precharge mode command cycle, both banks are prechareged. But A8=low in when A8=high in precharge command cycle, only one bank that is selected A9 (BS) is precharged. And when A8=high in read or write command cycle, the precharge cycle start automatically after the last data in bun;t accessing.

31,32 33,37

-

GND NC

Ground Not connected.

IC14

34

I

CKE

CKE detennine next CLK is valid or not. If CKE is high next CLK rising edge is valid. But if CKE is low, next CLK is invalid. If CLK rising edge is invalid, internal clock is not asserted and J.l PD4504161 becomes halt operation. And when J.l PD4502161 does not in bun;t mode and CKE is negated, J.l PD4502161 enter power down mode. During power down mode CKE must keep low level.

35

I

CLK

CLK is the master clock input pin. The other inputs signals are referenced at CLK rising edge.

VDP2

IC CUSTOM CHIP VDP2 QFP YAMAHA

IC CUSTOM CHIP VDP2 QFP HH

IC CUSTOM CP VDP2 S QFP YAMAHA

Parts No. : 315-5690

Parts No. : 315-5690-02

Parts No. : 315-5890

•Top View 120

• Block Diagram 81

scu 80

121 I I

VDP2

I 160

~ "

Bus control

40

Normal picture coordinate calculation

t--!-H GACTRL

CDIROMSKJ (Upper)

W·-r~t

T

~mrQ~b~

(Upper)

IRQ2 CTRL ADR DATA

OESCRAMBLE

CD SIGNAL PROCESSOR

'

RGB

'7 25

II Description No. I

2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

I I

I

1/0

Name

I

MVPRT MVR7 MVR6 MVR5 MVR4 MVR3 vee VSS MVG7 MVG6 MVG5 MVG4 MVG3 MVB7 vss MVB6 MVB5 MVB4 MVB3

I

I

I

I

I

I

I I

0 0 0 0

35 36 37

-

38 39 40 41 42 43 44 45

I I I I I

46 47 48 49 50 51 52 53 54 55 56

I

I

-

I

AAl AA2 AA3 VSS AA4 AA16 AA17 AA18 AeS2 WTRS vss FDACK MVCS MACS TP5 vee vss RESET MABieK MASDATAI MALRCLK TP2 seS6 vss SDLO SDLI SDL2 SDL3 SDL4 vee VSS SDLS SDL6 SDL7 SDLB SDL9 SDLIO

"Function

Video transparency control signal '

Video red color data

Power supply Ground

Video green color data

Video blue color data Ground

Video blue color data

A-BUS address bus Ground

A-BUS address bus

Chip select signal from A-BUS Wait control signal used to transfer MPEG video frame data Ground MPEG video frame data transfer control signal MPEG video chip select signal MPEG audio chip select signal Test pin Power supply Ground Gate array system reset signal Sync clock used to transfer MPEG audio serial data MPEG audio serial data signal Clock used to detect MPEG audio serial data L/R Test pin SH chip select 6 Ground

SH uP subdata bus

Power supply Ground

SH uP subdata bus

-67-

.. No. 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89

110

Name

-

vss SDLll SDL12

I

SDL13 SDL14 SDL15

-

vee vss

-

I

I

SA21 SA20 SA4 SA3 SA2 SRD

-

vss

I I

I I I

SHCK SAl IRQOUT SCS2 DACKl

-

vee vss

I

DACKO CASH

I I I I I

CASL SWRH SWRL SA19 TP3

-

vss

0 0 0

90

I

DSWR DREQ1 DREQO SDH15

91 92 . 93

-

vee

94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112

Function Ground

-

I

I

-

VSS SDH14 SDH13 SDH12 SDH11 SDH10 VSS SDH9

Power supply Ground

SH uP address bus

SH uP read enable signal Ground 20MHz clock SH uP address bus SH uP interrupt factor generation signal SH uP chip select 2 Channel 1 DMA transfer response Ground Channel 0 DMA transfer response DRAM control signal SH uP upper byte write enable signal SH uP lower byte write enable signal SH uP address bus Test pin Ground Delayed write cycle control signal Channel 1 DMA transfer request Channel 0 DMA transfer request SH uP main data bus Power supply Ground

SH uP main data bus

Ground Power supply

SDH8 SDH7 SDH6 SDH5

SH uP main data bus

vee vss

Power supply Ground

0

SDH4 SDH3 SDH2 SDH1 SDHO SIRQH

-

vss

I

SH uP subdata bus

SH uP main data bus

SH uP upper byte (CD-ROM) interrupt signal Ground

-68-

No.

1/0

113 114 115 116 117

0 0 0

118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 !56 157 158 159 160 161 162 163 164 165 166 167 168

I

i

I I

I

SIRQL BCK LRCK

-

vee

0 0

SD SUBCK

-

vee vss

I I I I I I

I

CFCKO SUBOUT SI DAS CKX MPX VSS C2F SMPX SDAS SCKX

-

vss vee vss

I

ATIM1 ATIMO

I I

'

I

I

I I I I

I

ARD VSS AFCO AWRO AWR1 AFCl

-

vss

0 0

AWAIT AIRQ

-

T ADO AD!

I

I

-

I

Functfon

Name

vee vss AD2 AD3 AD4 ADS VSS AD6 AD7 AD8 AD9

I

SH uP lower byte (A-BUS) interrupt signal Audio serial data sync clock Audio L!R channel switching signal Power supply Audio serial data Subcode input clock Power supply Ground Frame sync signal CD subcode data Subcode block sync signal CD-DA audio serial data CD audio serial data sync clock CD audio L!R channel switching signal C2 error flag CD-ROM data byte sync signal CD-ROM serial data CD-ROM serial data bit sync signal Ground Power supply Ground A-BUS timing control signal A-BUS read signal Ground A-BUS timing control signal A-BUS lower byte write signal A-BUS upper byte write signal A-BUS timing control signal Ground A-BUS wait control signal A-BUS interrupt signal Test signal for scan pass A-BUS data bus Power supply Ground

A-BUS data bus

Ground

A-BUS data bus

ADlO

I

-

vee VSS ADII AD12 AD13 ADI4 AD15

vss

Power supply Ground

A-BUS data bus

Ground

-69-

LODEDVIEW & PARTS LIST 11. EXP loded View ~ 54

I /_

11-1. Exp

- --:

6

1-2

4 5 21 r---.

I

-----,

-------~--

II I I I

I •

I I I

I

I

',

'I

[__--=----_-_-_-_-:_-_ r

I I

_I

- - -::..::. =::..-::..::.. ~

I

. . .,."'""""' i ~~:2J

I I

.1--·;--

I I

CNI

I I I I

I I

6

I I I

I

I

L__

A

c

B

- 70

···.~

j

0

11-2. Mechanical Parts List Ref. No.

Ref. No.

Description

Parts No.

[1] [2]

1 1

610-5862 610-5927

ASSY TOP CASE SATURN EUR ASSY TOP CASE SATURN AUS

1-1 1-2 1-3 1-4 1-5

610-5864 253-7015 253-7013 253-6917-03 253-6919-03

ASSY LID CD SATURN EUR TOP CASE SATURN EUR LID CRTG SATURN USA BUTTON OPEN SATURN USA BUTTON RESET SATURN USA

1-6 1-7 1-8 1-11 1-12

253-6920 253-7012 253-7010 601-7774 250-5404

BUTTON OPEN LEVER SATURN JPN MOUNT POWER UNIT PCB SAT USA PANEL DEC. FRONT SATURN USA OIL DUMPER SATURN BRACKET LEVER SATURN JPN

1-13 1-14 1-17 1-18 1-19

250-5423 250-5424A 125-5125 125-5126 125-5127

BRACKET LID CD SPRING SAT USA BRACKET LID CD HOLDER SAT USA A SPRING LID CD SATURN JPN SPRING LID CRTG SATURN JPN SPRING ARM SATURN JPN

1-20 1-21 1-22

510-5068 600-6536 601-7726

DETECTOR SW SPPB11 WIRE HARN 2P FOR DETECTOR USA PLATE SEVER SMALL SATURN JPN

2

610-5863

ASSY BOTTOM CASE SATURN USA

2-1

2-2

253-7016 601-7658

BOTTOM CASE SATURN EUR RUBBER FOOT SATURN JPN

3 5

837-11492 838-10834

ASSY IC BD SATURN VAO PAL IC BD SATURN SH1

6 6

610-5679-20 610-5679-21

ASSY CD DRIVE UNIT SATURN

7

7

400-5271 400-5272

AC POWER UNIT SATURN EUR AC POWER UNIT SATURN EUR

e,.7-1 e,.7-2

601-7672 514-5066

INLET FOR UL/CSA SATURN FUSE 1.6A 080026

10

253-6915-03

LID BATTERY SATURN EUR

11 11

253-6918-03 253-6918A-03

BUTTON POWER SATURN USA BUTTON POWER SATURN USA A

12 13 14 15 16

253-6921 253-6932 510-5069 601-7979 600-6416

MOUNT MECHA SATURN JPN SLIDE RAIL SATURN JPN POWER SW SDDLD PLATE SEVER LARGE SATURN USA WIRE HARN 5P FOR ST CD

17

600-6560

WIRE HARN 2P FOR P.SW NEW

18 18

600-6431 600-6431-01

FFC 20P L=180w.l FFC 20P L=180w.l

21 21

270-5094 270-5095

FERRITE CORE BP53RB120070060M FERRITE CORE L6 T12.5X5.5X7

38 39 40 41 42

250-5417 253-6922 029-000034 029-000034-0B 029-000035

BRACKET 9P BAT HOLDER B-TITE SCR B-TITE SCR B-TITE SCR

CONN HOLDER SATURN MATSUSHITA PH 3X8 PH BLK 3X8 PH 3X10

43 45 46 47

029-000035-0B 029-000036 029-000049 029-000061 029-000063

B-TITE 8-TITE B-TITE B-TITE S-TITE

SCR SCR SCR SCR SCR

PH BLK 3X10 PH 3X12 BRH 2.6X8 PH 3X14 Bl H2X4

48 49 50 51 52

029-000049 029-000049-0B 029-000052 029-000067-0B 029-000064

B-TITE B-TITE B-TITE B-TITE S-TITE

SCR SCR SCR SCR SCR

BRH 2.6X8 BRH BLK 2.6X8 PH 2X8 BRH BLK 2.6X6 PH 2X8

53

401-0054

BATTERY CR2032/1F

44

[Note] (1]····EUR [2]····AUSTRALIA

-71-

54

Parts No. 601-7815

Oeser ipt ion STAELE PROTECTION SHEET SAT

11 =3. Electrical Parts List Circuit No.

Circuit No.

Description

Parts No.

11-3-1. IC BD STATURN MAIN VAO USA

..

Description

Parts No.

IC31 IC31 IC31 IC31 IC31

315-0985-70 315-0986-70 315-0983-70 315-0984-70 315-1030-70

IC IC IC IC IC

UPD424260LE-70-E2 SOJ NEC TC514260BJ-70 SOJ TOSHIBA KM416C256BJ-7 SOJ SUMSUNG M8814260-70PJ-G SOJ FUJITSU HY514260BJC-70 SOJ HYUNDAI

IC32 IC32 IC32 IC32 IC32 IC32

315-0947-70 315-0985-70 315-0986-70 315-0983-70 315-0984-70 315-1030-70

IC IC IC IC IC IC

HM514260AJ-7 SOJ UPD424260LE-70-E2 SOJ NEC TC514260BJ-70 SOJ TOSHIBA KM416C256BJ-7 SOJ SUMSUNG MB814260-70PJ-G SOJ FUJITSU HY514260BJC-70 SOJ HYUNDAI

IC33

314-0634

IC 74HC157 SOP

IC34 IC34

313-5323 313-5323-01

IC UPC78L05T CHIP IC TA78L05F CHIP

IC35

313-5328

IC S-80723AN-DL CHIP

CN1 CN1

209-5070 209-5070A

EDGE CONN 134P N630-9523-T006 EDGE CONN 134P N630-9523-T006A

CN2 CN2XA CN2XB

209-5074 NOT USED NOT USED

CONN 9P*2 CSS5018-0101R NOT USED NOT USED

!Cl !Cl

315-0922A 315-0998

IC HD6417095F28 OFP IC HD6417095SF28 OFP

H!TACH! HITACHI

IC2 IC2

315-0922A 315-0998

IC HD6417095F28 OFP IC HD6417095SF28 OFP

HITACHI HITACHI

IC3 IC3 IC3

315-0928-17 315-1022-12 315-0928-15

IC HM5241605TT-17 TSOP HITACHI IC UPD4504161G5-Al2 TSOP NEC IC HM5241605TT-15 TSOP HITACHI

IC4 IC4 IC4

315-0928-17 315-1022-12 315-0928-15

IC HM5241605TT-17 TSOP HITACHI IC UPD4504161G5-A12 TSOP NEC IC HM5241605TT-15 TSOP HITACHI

IC5 IC6

315-5688 315-5778

IC CUSTOM CHIP SCU OFP YAMAHA IC CUSTOM CHIP DCC OFP TOSHIBA

IC7 IC7

EPR-17933 MPR-17933

OS SATURN IPL-ROM PAL DIP OS SATURN IPL-ROM PAL DIP

IC8 IC8 ICB ICB IC8

315-0948-10 315-0930-10 315-0964-10 315-0965-10 315-1002-70

IC IC IC IC IC

IC9

315-5744

IC CUSTOM CHIP SMPC QFP

CN3 CN4

212-5453 212-5440

CONN 6P B5P6-VH CONN lOOP FX6A-100S-0.8SV2

IClO IC10

315-5689 315-5883

IC CUSTOM CHIP VDP1 QFP IC CUSTOM CHIP VDPl S OFP

ICll IC11 IC11

315-0928-17 315-1022-12 315-0928-15

IC HM5241605TT-17 TSOP HITACHI IC UPD4504161G5-A12 TSOP NEC IC HM5241605TT-15 TSOP HITACHI

CN5 CN5 CN5X

212-5431 212-5481 NOT USED

MINI DIN CONN lOP FOR A/V HOSI MINI DIN lOP TCS7716-432010 NOT USED

IC12 IC12 IC12

315-0910-12 315-1017-17 315-1012-17

IC UPD4502161G5-A12 TSOP NEC IC HM5221605TT-17 TSOP HITACHI IC LC382161T-17 TSOP SANYO

CN6 CNB CN9 CNlO CNll

209-5075 212-5454 212-5454 NOT USED NOT USED

CONN liP TCX3072-010100 HOSHID CONN 5P B4(5)B-PH-K-S CONN 5P B4(5)B-PH-K-S NOT USED NOT USED

IC13 IC13 IC13

315-0910-12 315-1017-17 315-1012-17


CN12

212-5457

CONN 3P SJ21-03WT

Sl¥3

510-5063

TACT SYI SKEYAC

IC14 IC14 IC14

315-5690 315-5690-02 315-5890

IC CUSTOM CHIP VDP2 OFP YAMAHA IC CUSTOM CHIP VDP2 OFP HH IC CUSTOM CP VDP2 S OFP YAMAHA

Dl

481-5072

DIODE CHIP 1SS184

TOSHIBA

IC15 IC15 IC15

315-0910-12 315-1017-17 315-1012-17


D2 D2 D2

481-5168 481-5199 481-5201

DIODE CHIP HRYI0202A DIODE CHIP 1SS377 DIODE CHIP RB415D

HITACHI TOSHOBA ROHM

IC16 IC16 IC16

315-0910-12 315-1017-17 315-1012-17


D3 D3 D3

481-5168 481-5199 481-5201

DIODE CHIP HRW0202A DIODE CHIP 1SS377 DIODE CHIP RB415D

HITACHI TOSHIBA ROHM

D4 D5

481-5072 481-5179

DIODE CHIP 1SS184 DIODE CHIP MA153A

IC17 IC18

315-5687 315-0941

IC CUSTOM CHIP SCSP QFP YAMAHA IC MC68ECOOOFN12 PLCC MOTOROLA

06

IC19 IC19 IC19 IC19

315-0777-80 315-0739-70 315-0777-70 315-0822-80

IC IC IC IC

HITACHI HM514270AJ-8 SOJ NEC UPD424270LE-70 SOJ HITACHI HM514270AJ-7 SOJ MN414270SJ-08 SOJ PANASONIC

06

481-5168 481-5199 481-5201

DIODE CHIP HRW0202A DIODE CHIP 1SS377 DIODE CHIP RB415D

IC20 IC21 IC22 IC23 IC24

315-5746 313-5314 313-5313 314-0632 314-0632

IC IC IC IC IC

CUSTOM CHIP PLL HOFP SONY CXAI645M SOP PHI Ll PS TDA1386T SOP 74VHC04 SOP 300MIL 74VHC04 SOP 300MIL

TR1 TR2 TR3 TR4

482-5126 482-5125-01 482-5260 482-5260

XSTR XSTR XSTR XSTR

L1 L1

180-5137 180-5137-01

CHIP INDUCTOR 100UH 10~ KOA P.COIL CHIP 100UH ELJFA101KF

IC IC IC IC IC

S=80741AL=A5 CHIP 74LS245 SOP 300MIL 74LS245 SOP 300MIL 74ACT245 SOP 300MIL 74LS245 SOP 300MIL

CHIP INDUCTOR 100UH 10~ KOA P.COIL CHIP 100UH ELJFA101KF

IC27 IC28 IC29

313-5322 314-0563 314-0563 314-0649 314-0563

180-5137 180-5137-01

II"?~':

L2 L2 L3 L3

180-5142 180-5142-01

P.COIL CHIP IOOUH LOH3C101K04 P.COIL CHIP lOOUH NLFC322522T

180-5142 180-5142-01

P.COIL CHIP 100UH LOH3C101K04 P.COIL CHIP 100UH NLFC322522T

IC30

314-0563

IC 74LS245 SOP 300MIL

L4 L4

IC31

315-0947-70

IC HM514260AJ-7 SOJ

L5 LS

180-5142 180-5142-01

P.COIL CHIP lOOUH LOH3C101K04 P.COIL CHIP lOOUH NLFC322522T

'"'""" IC26

CXK58267AM-10L SOP UPD43257B-10LL SOP M5M5255BFP-12LL SOP SRM20257LLM10 SOP UM62257M-70LL SOP

SEIKO

D6

-72-

NEC TOSHIBA SEIKO

ALPS

TOSHIBA MATSUSHITA HITACHI TOSHIBA ROHM

2SC1623 L5 .. 7 CHIP NEC 2SA812 CHIP M5.. 6 NEC 2SD2114K(V.W)CHIP ROHM 2SD2114K(V.YI)CHIP ROHM

Circuit No.

Circuit No.

Description

Parts No.

Description

Parts No.

C11 C12 C13 C14 C15

151-0265 151-0265 151-0265 151-0265 151-0265

CAP CAP CAP CAP CAP

CER CER CER CER CER


C16 C17 C18 C19 C20

151-0265 NOT USED 151-0265 151-0265 151-0265

CAP NOT CAP CAP CAP

CER CP USED CER CP CER CP CER CP

NOT USED 476-2330-J-10 NOT USED NOT USED NOT USED

NOT RES NOT NOT NOT

USED CHIP 33 OHM 1/10\¥ 5% USED USED USED

C21 C22 C23 C24 C25

151-0307 151-0307 151-0621 151-0621 151-0305

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP 0. 022UF 50V ZF2125 CP 0. 022UF 50V ZF2125 CP 30PF 50V JCH2125 CP 30PF 50V JCH2125 CP 1000PF 50V KB2125

FBB FB9 FB10 F813 FB15

NOT NOT NOT NOT NOT

NOT NOT NOT NOT NOT

USED USED USED USED USED

C26 C27 C28 C29 C30

151-D521 151-0318 151-0307 151-0307 151-0478

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP 470PF CHIP 33PF CP 0.022UF CP 0. 022UF CP 27PF

FB16 F817 F818

NOT USED NOT USED 479-5005-0000

NOT USED NOT USED RES CHIP 0 OHM 1/10W 2125

EM12 EMI3 EMI5 EM16 EM17

271-0045 271-0045 271-0045 271-0045 271-0045

EMI EM! EMI EM! EM!

FILTER FILTER FILTER FILTER FILTER

STB101KB STB101KB STB101KB STB101KB STB101KB

~AI YO TAl YO TAl YO TAIYO TAIYO

C31 C32 C33 C34 C35

151-0377 151-0307 NOT USED NOT USED 151-D320

CAP CAP NOT NOT CAP

CER CP 100PF 50V KCH2125 CER CP 0.022UF 50V ZF2125 USED USED CER CP 68PF 50V J CH2125

EMIB EM19 EMI10 EMI11 EM112

271-0045 271-0045 271-0045 271-0045 271-0045

EM! EMI EMI EMI EMI



TAl YO TAl YO TAIYO TAIYO TAl YO

C36 C37 C38 C39 C40

NOT USED 151-0265 151-0265 151-0265 151-0270

NOT CAP CAP CAP CAP

USED CER CP CER CP CER CP CER CP

0. 1UF 0. 1UF 0. 1UF 47PF

25V 25V 25V 50V

ZF2125 ZF2125 ZF2125 KSL2125

EM113 EM114 EMI15 EM116 EM117

271-0045 271-0045 271-0045 271-0045 271-0045

EM! EM! EMI EMI EM!



TAl YO TAl YO TAl YO TAl YO TAIYO

C41 C42 C43 C44 C45

151-0S92 151-0265 151-0265 151-0361 NOT USED

CAP CAP CAP CAP NOT

CER CP CER CP CER CP CER CP USED

5PF/50V 0. lUF 25V 0. 1UF 25V 15PF 50V

CCH2125 ZF2125 ZF2125 CH2125

EM118 EM119 EM120 EM121 EM122

271-0045 271-0045 271-0045 271-0045 271-0045

EM! EMI EM! EM! EM!



TAIYO TAIYO TAl YO TAIYO TAl YO

C46 C47 C48 C49 C50

NOT USED 1S1-0318 NOT USED NOT USED 151-0319

NOT CAP NOT NOT CAP

USED CER CHIP 33PF 50V CH2125 USED USED CER CHIP 20PF 50V CH2125

EM123 EMI24 EM125 EMI26 EMI27

271-0045 271-0045 271-0045 271-0045 271-0045

EM! EM! EMI EM! EM!


STB101KB STB101KB STB101KBSTB101KB STB101KB

TAIYO TAIYO TAIYO TAIYO TAIYO

C51 CS2 C53 C54 C55

1S1-0319 1S1-026S 1S1-026S 1S1-026S 1S1-0265

CAP CAP CAP CAP CAP

CER CER CER CER CER

CHIP CP CP CP CP

20PF 0. 1UF 0. 1UF 0. 1UF 0. 1UF

50V 25V 25V 2SV 25V

CH2125 ZF212S ZF2125 ZF2125 ZF2125

EMI28 EMI29 EMI30 EM131

EM! EMI EMI EMI EMI



TAl YO TAIYO TAIYO TAIYO TAIYO

1S1-026S 151-026S 1Sl-026S 1S1-026S 1S1-026S

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP CP CP CP CP

0. 1UF 0. 1UF 0. 1UF 0. lUF 0. 1UF

25Y 25V 2SY 2SV 2SV

ZF2125 ZF2125 ZF2125 ZF212S ZF2125

E~dl32

271-004S 271-004S 271-0045 271-004S 271-0045

CS6 C57 C58 C59 C60

EMI33 EM134 EM13S

271-0045 271-004S 271-0045

EM! FILTER STB101KB EMI FILTER STB101KB EM! FILTER STB101KB

TAIYO TAIYO TAIYO

C61 C62 C63 C64 C6S

151-026S 1S1-026S 1Sl-0305 1S1-030S NOT USED

CAP CAP CAP CAP NOT

CER CP 0. 1UF 2SY CER CP 0. 1UF 2SV CER CP lOOOPF SOY CER CP 1000PF 50V USED

ZF212S ZF2125 KB2125 KB212S

C1 C2 C3 C4

1S1-0307 1S1-0S21 1S1-026S 1S1-0307 151-0S21

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP 0.022UF SOY ZF212S CP 470PF SOY SL2125 CP 0. 1UF 2SY ZF212S CP 0.022UF SOY ZF212S CP 470PF SOY SL212S

C66 C67 C68 C69 C70

151-026S 1S1-026S 1S1-026S 1S1-026S 1S1-026S

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP CP CP CP CP

0. 1UF 0. 1UF 0. lUF 0. 1UF 0. 1UF

25V 25V 2SY 2SY 2SY

ZF212S ZF2125 ZF212S ZF212S ZF2125

C6 C7

1S1-0265 151-026S 151-026S 1S1-026S 151-026S

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP CP CP CP CP

C71 C72 C73 C74 C75

1S1-026S 1S1-026S 151-0265 1S1-0265 151-0265

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP CP CP CP CP

0. lUF 0. 1UF 0. 1UF 0. 1UF 0. 1UF

2SV 2SV 25V 2SV 25V

ZF212S ZF212S ZF2125 ZF212S ZF2125

C76 C77

1S1-026S 1S1-026S

CAP CER CP CAP CER CP

L6 L6

180-5142 180-5142-01

P. COIL CH I.P 1OOUH LOH3C1 01 K04 P. COIL CHIP 100UH NLFC322522T

L8 L8

180-5142 180-5142-01

P. COIL CHIP 100UH LOH3C101K04 P. COIL CHIP 100UH NLFC322522T

L9 L9

180-5142 180-5142-01


L10 L10

180-5142 180-5142-01

FB3 FB4 FB5 FB6 FB7

cs

CB

C9 C10


0. 1UF 0. 1UF 0. lUF 0. 1UF 0. 1UF

2SY 2SV 25Y 25Y 25V

ZF2125 ZF2125 ZF2125 ZF2125 ZF2125

-73-

CP CP CP CP CP

0. 1UF 0. 1UF 0. 1UF 0. 1UF 0. 1UF

ZF2125 ZF2125 ZF2125 ZF2125 ZF2125

25V 25V 25V 25V 25V

0. 1UF 25V ZF2125 0. 1UF 25V ZF2125 0. 1UF 25V ZF2125 0. 1UF 25V ZF2125

50V 50V 50V 50V 50V

SL2125 CH2125 ZF2125 ZF2125 CH2125

0. 1UF 2SV ZF2125 0. 1UF 2SV ZF212S

Circuit No.

Circuit No.

Description

Parts No.

C78 C79 C80

151-0265 151-0265 151-0265

CAP CER CP CAP CER CP CAP CER CP

0. lUF 25V ZF2125 0. 1UF 25V ZF2125 0. 1UF 25V ZF2125

C81 C82 C83 C84 C85

151-0265 151-0265 151-0265 151-0265 151-0265

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP CP CP CP CP

0. 1UF 0. 1UF 0. 1UF 0. 1UF 0. 1UF

25V 25V 25V 25V 25V

ZF2125 ZF2125 ZF2125 ZF2125 ZF2125

C86 C87 C88 C89 C90

151-0265 151-0265 151-0265 151-0265 151-0265

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP CP CP CP CP

0. 1UF 0. 1UF 0. 1UF 0. lUF 0. 1UF

25V 25V 25V 25V 25V

ZF2125 ZF2125 ZF2125 ZF2125 ZF2125

C91 C92 C93 C94 C95

151-0265 NOT USED NOT USED NOT USED NOT USED

CAP NOT NOT NOT NOT

CER CP USED USED USED USED

0. 1UF 25V ZF2125

C96 C97 C98 C99 C102

151-0270 NOT USED NOT USED NOT USED NOT USED

CAP NOT NOT NOT NOT

CER CP USED USED USED USED

47PF SOY KSL2125

C103 C104 C105 C106 C107

151-0265 151-0265 151-0265 151-0265 151-0265

CAP CAP CAP CAP CAP

CER CER CER CER CER

C108 C109 C110 C111 C112

151-0265 151-0298 151-0298 151-0592 NOT USED

CAP CAP CAP CAP NOT

C114 C115 C116 C117 C118

NOT USED 151-0265 151-0265 151-0265 151-0265

C119 C120 C121 Cl22 C123

CP CP CP CP CP

25V 25V 25V 25V 25V

ZF2125 ZF2125 ZF2125 ZF2125 ZF2125

CER CP CER CP CER CP CER CP USED

0. 1UF 25V lOOPF SOV 100PF SOV 5PF/50V

ZF2125 JSL2125 JSL2125 CCH2125

NOT CAP CAP CAP CAP

USED CER CP CER CP CER CP CER CP

0. 1UF 0. 1UF 0. 1UF 0. lUF

25V 25V 25V 25V

ZF2125 ZF2125 ZF2125 ZF2125

151-0265 151-0265 151-0298 151-0298 151-0298

CAP CAP CAP CAP CAP

CER CER CER CER CER

0. 1UF 0. 1UF 100PF 100PF 100PF

25V 25V SOV 50V SOY

ZF2125 ZF2125 JSL2125 JSL2125 JSL2125

C124 C125 C126 C127 C129

151-0298 NOT USED NOT USED 151-0265 151-0320

CAP NOT NOT CAP CAP

CER CP USED USED CER CP CER CP

C130 C131 C132 C133 C134

151-0623 151-0623 151-0623 151-0623 151-0623

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP CP CP CP CP

1UF 1UF lUF 1UF "1UF

16V 16V 16V 16V 16V

ZF2125 ZF2125 ZF2125 ZF2125 ZF2125

C135 C136 C137 C138 C139

151-0623 151-0623 151-0623 151-0623 151-0623

CAP CAP CAP CAP CAP

CER CER CER CER CER

CP CP CP CP CP

1UF 1UF 1UF 1UF 1UF

16V 16V 16V 16V 16V

ZF2125 ZF2125 ZF2125 ZF2125 ZF2125

C140 C141

151-0623 151-0623

CAP CER CP 1UF 16V CAP CER CP lUF 15¥

ZF2125 ZF2125

CE1 CE2

151-0623 151-0622

CAP CER CP 1UF 16V CAP CER CP IUF 16V

ZF2125 ZF3216

CE3 CE3 CE3 CE3

150-0313-04 150-0313-01 150-0313-03 150-0313-05

CAPE CAPE CAPE CAPE

CP CP CP CP

CP CP CP CP CP

0. 1UF 0. 1UF 0. 1UF 0. 1UF 0. 1UF

100PF SOY JSL2125 ·-

0. 1UF 25V ZF2125 68PF 50V J CH2125

100UF6.3V MV6.3VC100M 100UF 6.3V ECEVOJA101 100UF6.3V UWXOJ101MCR 100UF 6.3V REV

-

Parts No.

Desc r ipt ion

CE4

151-0622

CAP CER CP 1UF 16V

CE6 CE6 CE6 CE6

150-0313-04 150-0313-01 150-0313-03 150-0313-05

CAPE CAPE CAPE CAPE

CE15 CE15 CE15 CE15

150-0464 150-0464-01 150-0464-02 150-0464-03

CE16 CE16 CE16 CE16

ZF3216

CP CP CP CP


CAP CAP CAP CAP

E CP E CP E CP E CP

10UF16V MV16VC10MD55 10UF 16V ECEV1CA100 10UF 16V UWX1C100MCR1 10UF16V REV

150-0464 150-0464-01 150-0464-02 150-0464-03

CAP CAP CAP CAP

E CP E CP E CP E CP


CE18 CE18 CE18 CE18

150-0313-04 150-0313-01 150-0313-03 150-0313-05

CAPE CAPE CAPE CAPE

CP CP CP CP


CE19 CE19 CE19 CE19

150-0313-04 150-0313-01 150-0313-03 150-0313-05

CAPE CAPE CAPE CAPE

CP CP CP CP


CE20 CE20 CE20 CE20

15Qr.0464 150:.0464-01 150-0464-02 150-0464-03

CAP CAP CAP CAP

E CP E CP E CP E CP


CE21 CE21 CE21 CE21

150-0464 150-0464-01 150-0464-02 150-0464-03

CAP CAP CAP CAP

E CP E CP E CP E CP


CE22 CE22 CE22 CE22

150-0496 150-0496-01 150-0496-02 150-0496-03

CAP CAP CAP CAP

E CP E CP E CP E CP

4. 7UF 25V MV25VC4R7M 4. 7UF 25V ECEV1EA4R7 4. 7UF25V UWX1E4R7MCR1 4. 7UF25V REV

CE23 CE23 CE23 CE23

150-0464 150-0464-01 150-0464-02 150-0464-03

CAPE CP CAP E CP CAP E CP CAP E CP


CE24 CE24 CE24 CE24

150-0423 150-0423-01 150-0423-02 150-0423-03

CAP CAP CAP CAP

E CP E CP E CP E CP

220UF 220UF 220UF 220UF

4V MV4VC220MF55 4V ECEVOGA221 4V UWXOG221MCR1 4V REV

CE25 CE25 CE25 CE25

150-0423 15D-0423-01 150-0423-02 150-0423-03

CAP CAP CAP CAP

E CP E CP E CP E CP

220UF 220UF 220UF 220UF


CE26 CE26 CE26 CE26

150-0423 150-0423-01 150-0423-02 150-0423-03

CAP CAP CAP CAP

E CP E CP E CP E CP

220UF 220UF 220UF 220UF


CE27 CE27 CE27 CE27

150-0423 150-0423-01 150-0423-02 150-0423-03

CAP CAP CAP CAP

E CP E CP E CP E CP

220UF 220UF 220UF 220UF


CE28 CE28 CE28 CE28

150-0423 150-0423-01 150-0423-02 150-0423-03

CAP CAP CAP CAP

E CP E CP E CP E CP

220UF 220UF 220UF 220UF


CE29 CE29 CE29 CE29

150-0423 150-0423-01 150-0423-02 150-0423-03

CAP CAP CAP CAP

E CP E CP E CP E CP

220UF 220UF 220UF 220UF


CE30

150-0505-02

CAP E CP 220UF10V UUR1A221MBR

CE31

150-0464

CAP E CP 10UF16V MV16VC10MD55

-74-

Circuit I No. I

Circuit I No.

Description

Parts No.

Desc r ipt ion

Parts No. i

R21 R22 R24 R25 R26

476-2222-J-10 476-2111-J-1 0 476-2303-J-10 476-2303-J-10 476-2362-J-10

RES RES RES RES RES

CHIP CHIP CHIP CHIP CHIP

R27 R28 R29 R30 R31

476-2363-J-10 476-2621-J-10 NOT USED 476-2102-J-10 476-2102-J-10

RES RES NOT RES RES

CHIP 36KOHM 1/10\1' 5% CHIP 620 OHM 1/10\1' 5% USED CHIP 1KOHM 1/10\1' 5% CHIP 1KOHM 1/10\1' 5%

R32 R33 R35 R36 R37

476-2102-J-10 476-2222-J-10 476-2473-J-10 476-2750-J-10 476-2750-J-10

RES RES RES RES RES


1KOHM 2. 2KOHM 47KOHM 75 OHM 75 OHM

1/10\1' 1/10\1' 1/10\1' 1/10\1' 1/10\1'

5% 5% 5% 5% 5%

47UF 6.3V MV6.3VC47M 47UF 6.3V ECEVOJA470 47UF6. 3V UWXOJ470MCR1 47UF 6.3V REV

R38 R39 R40 R41 R42

476-2750-J-10 476-2750-J-10 476-2750-J-10 476-2750-J-10 476-2163-F-10

RES RES RES RES RES


75 OHM 75 OHM 75 OHM 75 OHM 16KOHM

1/10\1' 1/10\1' 1/10\1' 1/10\1' 1/10\1'

5% 5% 5% 5% 1%


R43 R44 R45 R46 R47

476-2101-J-10 476-2101-J-10 476-2104-J-10 476-2104-J-10 476-2472-J-10

RES RES RES RES RES


100 OHM 100 OHM 100KOHM 100KOHM 4. 7KOHM

1/10\1' 1/10\1' 1/10\1' 1/10\1' 1/10\1'

5% 5% 5% 5% 5%

10UF 10UF 10UF 10UF

R48 R49 R50 R66 R67

476-2201-J-10 476-2472-J-10 476-2472-J-10 476-2472-J-10 476-2105-J-10

RES RES RES RES RES


200 OHM 4. 7KOHM 4. 7KOHM 4. 7KOHM 1MOHM

1/10\1' 1/10\1' 1/10\1' 1/10\1' 1/1 0\1'

5% 5% 5% 5% 5%

R68 R69 R74 R96 R97

476-2334-J-10 476-2103-J-10 476-2103-J-10 NOT USED NOT USED

RES RES RES NOT NOT

CHIP 330KOHM 1/10\1' 5% CHIP 10KOHM 1/10\1' 5% CHIP 10KOHM 1/10W 5% USED USED

R98 R99 R100 R101 R102

476-2103-J-10 NOT USED 476-2103-J-10 476-2103-J-10 476-2103-J-10

RES NOT RES RES RES

CHIP USED CHIP CHIP CHIP

10KOHM 1/10\1' 5% 10KOHM 1/10'11 5% 1OKOHM 1/1 OW 5%

MV6.3VC47M ECEVOJA470 UWXOJ470MCR1 REV

R103 R104 R105 R106 R107

476-2103-J-10 476-2103-J-10 476-2103-J-10 476-2103-J-10 476-2103-J-10

RES RES RES RES RES


10KOHM 10KOHM 10KOHM 10KOHM 10KOHM

1/10W 1/10\1' 1/10\1' 1/10W 1/10\1'

5% 5% 5" 5" 5%


R108 R109 R110 R111 R112

476-2103-J-10 476-2103-J-10 476-2103-J-10 476-2103-J-10 476-2103-J-10

RES RES RES RES RES


10KOHM 1OK OHM 10KOHM 10KOHM 10KOHM

1/10\1' 1/1 OW 1/10\1' 1/10W 1/10\1'

5" 5" 5" 5" 5%

R113 R114 R115 R116 R117

476-2103-J-10 NOT USED NOT USED NOT USED NOT USED

RES NOT NOT NOT NOT

CHIP 10KOHM 1/10\1' 5% USED USED USED USED

CAP E CP 100UF lOY UWX1AMCR1 CAP E CP lOOUF lOY UUR1A101MCR

R118 R119 R120 R121 R122

NOT USED NOT USED 476-2103-J-10 NOT USED 476-2103-J-10

NOT NOT RES NOT RES

USED USED CHIP 10KOHM 1/10\1' 5% USED CHIP lOKOHM 1/10W 5%

476-2101-J-10 476-2101-J-10 476-2101-J-10 476-2302-J-10 476-2302-J-10

RES RES RES RES RES

CHIP 100 OHM 1/10\1' 5% CHIP 100 OHM 1/lOW 5% CHIP 100 OHM 1/lOW 5% CHIP 3KOHM 1/10W 5% CHIP 3KOHM 1/10W 5%

R124 R125 R126 R127 R128

476-2472-J-10 476-2472-J-10 476-2101-J-10 476-2101-J-10 476-2101-J-10

RES RES RES RES RES


476-2105-J-10 476-2680-J-10

RES CHIP 1MOHM 1/10W 5% RES CHIP 68 OHM 1/10\1' 5%

R129 R130

476-2101-J-10 476-2101-J-10

RES CHIP 100 OHM 1/10W 5" RES CHIP 100 OHM 1/10W 5"

CE31 CE31 CE31

150-0464-01 150-0464-02 150-0464-03

CAP E CP 10UF 16V ECEV1CA100 CAP E CP 10UF 16V UWX1C100MCR1 CAP E CP 10UF16V REV

CE32 CE32 CE32 CE32

153-0120 153-0120-01 153-0120-02 153-0120-03

CAP CAP CAP CAP

CE33 CE33 CE33 CE33

150-0494 150-0494-01 150-0494-02 150-0494-03

CAPE CP CAPE CP CAP E CP CAPE CP

22UF 6.3V MV6.3VC22M 22UF 6.3V ECEVOJA220 22UF6. 3V UWXOJ220MCR1 22UF 6.3V REV

CE34 CE34 CE34 CE34

150-0494 150-0494-01 150-0494-02 150-0494-03

CAPE CAPE CAPE CAPE

CP CP CP CP

22UF 6.3V MV6.3VC22M 22UF 6.3V ECEVOJA220 22UF6.3V UWXOJ220MCR1 22UF 6.3V REV

CE35 CE35 CE35 CE35

150-0501 150-0501-01 150-0501-02 150-0501 -03

CAPE CP CAPE CP CAP E CP CAPE CP

CE37 CE37 CE37 CE37

150-0464 150-0464-01 150-0464-02 150-0464-03

CAP CAP CAP CAP

CE38

NOT USED

NOT USED

CE42 CE42 CE42 CE42

150-0464 150-0464-01 150-0464-02 150-0464-03

CAP CAP CAP CAP

CE45 CE46

150-0504 150-0504

CAP E 330UF CAP E 330UF

CE47 CE47 CE47 CE47

150-0463 150-0463-01 150-0463-02 150-0463-03

CAP CAP CAP CAP

E CP E CP E CP E CP

1UF 1UF 1UF 1UF

50V MV50VC1MD55 50V ECEV1HA010 50V UWX1H010MCR1 50V REV

CE48 CE48 CE48 CE48

150-0463 150-0463-01 150-0463-02 150-0463-03

CAP CAP CAP CAP

E CP E CP E CP E CP

1UF 1UF 1UF 1UF

50V MV50VC1MD55 50V ECEV1HA010 50V UWX1H010MCR1 50V REV

CE49 CE49 CE49 CE49

150-0501 150-0501-01 150-0501-02 150-0501-03

CAPE CAPE CAPE CAPE

CP CP CP CP

47UF 47UF 47UF 47UF

6.3V 6.3V 6.3V 6.3V

CE50 CE50 CE50 CE50

150-0501 150-0501-01 150-0501-02 150-0501-03

CAPE CAPE CAPE CAPE

CP CP CP CP

47UF 47UF 47UF 47UF

6.3V 6.3V 6.3V 6.3V

CE52 CE52 CE52 CE52

150-0464 150-0464-01 150-0464-02 150-0464-03

CAP CAP CAP CAP

E CP E CP E CP E CP

10UF 10UF 10UF 10UF

16V MV16VC10MD55 16V ECEV1CA100 16V UWX1C100MCR1 16V REV

CE53 CE53 CE53 CE53

150-0501 150-0501-01 150-0501-02 150-0501-03

CAPE CAPE CAPE CAPE

47UF 47UF 47UF 47UF

6.3V 6.3V 6.3V 6.3V

CE54 CE54

150-0520-03 150-0522-03

Rl R2 R3 R4 R5 R19 R20

TANT TANT TANT TANT

E CP E CP E CP E CP E CP E CP E CP E CP

CP CP CP CP

CHIP CHIP CHIP CHIP

10UF 10UF 10UF 10UF

6.3V NEC 6. 3V PANA 6.3V NICHI 6.3V TO\\' A

16V MV16VC10MD55 16V ECEV1CA100 16V UWX1C100MCR1 16V REV USROJ331MCA1TD USROJ331MCA1TD


-75-

2.2KOHM 110 OHM 30KOHM 30KOHM 3.6KOHM

1/10\1' 1/10\1' 1/10\1' 1/10\1' 1/10\1'

5% 5% 5% 5% 5%

10KOHM 1/10'11 5%

4. 7KOHM 4. 7KOHM 100 OHM 100 OHM 100 OHM

1/10W 1/10'11 1/10W 1/10W 1/10W

5" 5% 5" 5% 5%

Circuit I No. ,

Parts No.

Description

I

Circuit No.

Desc r ipt ion

Parts No.

r

10KOHM 10KOHM lOKOHM 10KOHM lOKOHM

1/101'1 1/101'1 1/101'1 1/101'1 1/101'1

5% 5% 5% 5% 5%

R131 R132 R133 R134 R135

476-2103-J-10 476-2103-J-10 476-2103-J-10 476-2103-J-10 476-2103-J-10

RES RES RES RES RES


R136 R137 R138 R139 R140

1476-2361-J-10 476-2104-J-10 476-2103-J-10 NOT USED 476-2301-J-10

RES RES RES NOT RES

CHIP CHIP CHIP USED CHIP

300 OHM 1/lOW 5%

R141 R142 R143 R144 R145

476-2512-J-10 476-2222-J-10 476-2511-J-10 476-2511-J-10 476-2103-J-10

RES RES RES RES RES


5. 1KOHM 2.2KOHM 510 OHM 51D OHM 1OKOHM

1/101'1 1/101'1 1/101'1 1/101'1 1/101¥

5% 5% 5% 5% 5%

R146 R147 R148 R149 R150

476-2103-J-10 476-2103-J-10 476-2391-J-10 476-2224-J-10 476-2511-J-10

RES RES RES RES RES


10KOHM lOKOHM 390 OHM 220KOHM 510 OHM

1/101'1 1/101'1 1/101'1 1/lOW 1/lOW

5% 5% 5% 5% 5%

R151 R152 R153 R154 R155

476-2511-J-1 0 476-2103-J-10 NOT USED NOT USED NOT USED

RES RES NOT NOT NOT

CHIP 510 OHM 1/101'1 5% CHIP 1OK OHM 1/1 OW 5% USED USED USED

R156 R157 R158 R160

NOT USED NOT USED NOT USED 479-5005-0000

NOT NOT NOT RES

USED USED USED CHIP

RA1 RAJ RAl

477-0170 477-0170-02 477-0170-01

R-PK CP 8*10KOHM 1/161'1 5% 1'1/C R-PK CP 8*10KOHM 1/161'1 5% 1'1/C R-PK CP 8*10KOHM 1/161'1 5% 1'1/C

RA2 RA2 RA2

477-0170 477-0170-02 477-0170-01

R-PK CP 8*10KOHM 1/161\' 5% 1'1/C R-PK CP 8*10KOHM 1/161'1 5% W/C R-PK CP 8*10KOHM 1/161'1 5% W/C

RA3 RA3 RA3

477-0170 477-0170-02 477-0170-01

R-PK CP 8*10KOHM 1/161'1 5% W/C R-PK CP 8*10KOHM 1/161'1 5% W/C R-PK CP 8*10KOHM 1/161'1 5% W/C

RA4 RA4 RA4

477-0170 477-0170-02 477-0170-01

R-PK CP 8*10KOHM 1/16W 5% W/C R-PK CP 8*10KOHM 1/161'1 5% W/C R-PK CP 8*10KOHM 1/161'1 5% W/C

RA5 RA5 RA5

477-0170 477-0170-02 477-0170-01

RA6 RA6 RA6

477-0170 477-0170-02 477-0170-01

R-PK CP 8*10KOHM 1/161'1 5% W/C R-PK CP 8*10KOHM 1/161'1 5% W/C R-PK CP 8*10KOHM 1/161'1 5% 1'1/C ·• R-PK CP B*lOKOHM 1/161'1 5% W/C R-PK CP 8*10KOHM 1/161'1 5% W/C R-PK CP 8*10KOHM 1/161'1 5% W/C

RA7 RA7 RA7

477-0170 477-0170-02 477-0170-01

R-PK CP 8*10KOHM 1/161'1 5% W/C R-PK CP 8*10KOHM 1/161'1 5% 1'1/C R-PK CP 8*10KOHM 1/161'1 5% 1'1/C

RA8 RA8 RA8

477-0170 477-0170-02 477-0170-01

R-PK CP 8*10KOHM 1/161'1 5% 1'1/C R-PK CP 8*10KOHM 1/161'1 5% W/C R-PK CP 8*10KOHM 1/161'1 5% 1'1/C

XI

230-5202

OSC XTAL 17. 7344MHZ +-20PPM

X2 X3 X4

NOT USED 230-5169 230-5170-01

NOT USED CERAMIC RESONATOR CST4.00MGW XTAL 32. 768KHZ +-20PPM SEIKO

JPl JP2 JP3 JP4 JP5

NOT USED 476-2104-J-10 NOT USED NOT USED NOT USED

NOT RES NOT NOT NOT

JP6

NOT USED

NOT USED

360 OHM 1/101'1 5% 100KOHM 1/101'1 5% 10KOHM 1/101'1 5%

0 OHM 1/101\' 2125

USED CHIP 100KOHM 1/10W USED USED USED

50~

JP7 JP8 JP9 JP10

NOT NOT NOT NOT

USED USED USED USED

NOT NOT NOT NOT

USED USED USED USED

JP11 JP12 JP13 JP14 JP15

NOT USED NOT USED NOT USED 514-5069 514-5069

NOT NOT NOT RES RES

USED USED USED CHIP CHIP

JP16 JP17 JP18 JP19 JP20

514-5069 514-5069 NOT USED NOT USED 476-2102-J-10

RES RES NOT NOT RES

CHIP CHIP USED USED CHIP

JP21 JP22

NOT USED NOT USED

NOT USED NOT USED

1c som

213-0113

IC SOCKET 40PIN ICE-406-S-TG

BS HOL t 029-000034-08 BS HOL 029-000034-08 FUSE

600-6458

0 OHM 1/101'1 2125 0 OHM 1/10W 2125 0 OHM 1/101'1 2125 0 OHM 1/10W 2125 lKOHM 1/10W 5%

T

8-TITE SCR PH BLK 3X8R 8-TITE SCR PH BLK 3X8R JUMPER WIRE L=lOMM

11-3-2. SATURN POWER INDICATOR BD VAO CN13

600-6452

\\'IRE HARN 2P FOR POWER LED

LDl

390-5511

LED SL8-25MG GREEN

11-3-3. SATURN R.SW BD VAO LD2

390-5568

LED SL8-25DL13F ORANGE

SWl

510-5063

TACT SW SKEYAC

CN14

600-6451

WIRE HARN 5P FOR RESET 8T

11-3-4. PC BD SH1 FOR SATURN IC101 IC101

315-5785 315-5785A

IC CUSTOM CHIP SHl OFP IC CUSTOM CHIP SH1A QFP

IC102 IC103

315-0947-80 315-5873

IC HM514260AJ-8 SOJ IC CUSTOM CHIP OCU YGR019A

E101 E102

212-5473 212-5474

CONN lOOP FX6-100P-0.8SV2 CONN 20P SD-52610-2017

L101

NOT USED

NOT USED

ClOl C102 C103 C104 C105

NOT USED NOT USED 151-0430 151-0430 151-0418

NOT NOT CAP CAP CAP

USED USED CER CP lOPF 50V CH1608 1OPF 50V CH1608 CER CP CER CP 0.01UF/50V BK1608

C106' C107 C108 C109 CllO

151-0418 151-0418 NOT USED 151-0418 NOT USED

CAP CAP NOT CAP NOT

CER CP 0. 01UF/50V 8K1608 CER CP 0. 01UF/50V 8K1608 USED CER CP 0.01UF/50V BK1608 USED

C111 Cl12

C113

C114 C115

151-0418 NOT USED NOT USED NOT USED 151-0418

CAP NOT NOT NOT CAP

CER CP 0. 01UF/50V 8K1608 USED USED USED CER CP 0.01UF/50V 8K1608

C116 C117 Cl18 C119 C120

NOT USED NOT USED 151-0418 151-0418 151-0418

NOT NOT CAP CAP CAP

USED USED CER CP 0. 01UF/50V BK1608 CER CP 0.01UF/50V BK1608 CER CP 0.01UF/50V BK1608

-76-

11-4. Accessories/Package List Circuit No.

Parts No.

Description

I

C121 C122 C123 Cl24 C125

150-0501 NOT USED 151-D418 NOT USED NOT USED

CAP NOT CAP NOT NOT

E CP 47UF 6. 3V MV6. 3VC47M USED CER CP 0. 01UF/50V BK1608 USED USED

C126 Cl27 C128 C129 C130

NOT NOT NOT NOT NOT

NOT NOT NOT NOT NOT


C131 C132

NOT USED NOT USED

NOT USED NOT USED

R101 R102 R103 R104 R105

476-1103-J-16 476-1103-J-16 476-1103-J-16 476-1103-J-16 476-1103-J-16

RES RES RES RES RES


10KOHM 10KOHM 1OK OHM 1OKOHM 10KOHM

1/16W 1/16W 1/161'1 1/161'1 1/161'1

5% 5% 5% 5% 5%

R106 R107 R108 R109 R110

476-1472-J-16 476-1472-J-16 476-1472-J-16 476-1222-J-16 476-1472-J-16

RES RES RES RES RES


4. 7KOHM 4. 7KOHM 4. 7KOHM 2.2KOHM 4. 7KOHM

1/161'1 1/16W 1/161'1 1/161'1 1/161'1

5% 5% 5% 5% 5%

R111 R112 R113 R114 R115

NOT USED NOT USED 476-1330-J-16 NOT USED NOT USED

NOT NOT RES NOT NOT

USED USED CHIP 33 OHM 1/161'1 5% USED USED

R116 R117 R118 R119

NOT NOT NOT NOT

USED USED USED USED

NOT NOT NOT NOT

USED USED USED USED

RM101 RM102 RM103 RM104

477-0141-01 477-0141-01 477-0141-01 477-0141-01

R-PK R-PK R-PK R-PK

CP CP CP CP

X101

230-5196

XTAL 20MHZ

CN1

209-5077

EDGE CONN lOOP N630-9523-T005


4*330HM 4*330HM 4*330HM 4*330HM

1/16W 1/16W 1/16W 1/161'1

No.

Oeser i pt ion

Parts No.

1

610-5861

ASSY CP SAT EUR

2 2

6D0-6540 600-6540-01

RGB CABLE SATURN PAL RGB CABLE SATURN PAL V2

[A, B] [A, B]

3

610-5865

RF UNIT STURN TOWA PAL-G/1

[CJ

4 4 4 4

600-6537 600-6538 600-6538-01 600-6571

AC AC AC AC

5 5 5

672-2359A 672-2359B 672-2450A

MANUAL HARD SATURN MULTI A MANUAL HARD SATURN MULTI B MANUAL HARD SATURN AUS A

6 7

SGM-4349 SGM-4363

POLY BAG 340*340*0.05 EXP 6 POLY BAG 200*310*0.05 EXP 6

CABLE CABLE CABLE CABLE

[Note] [A] · · · ·UK [BJ .... SOE [C]·· ··AUSTRALIA

5% 5% 5% 5% SMD-49

-77-

SATURN SATURN SATURN SATURN

PLUG=MF PLUG=C PLUG=C PLUG=S

[A] [8]

[BJ [C] [A, BJ [A. B] [C]

II

© 1995 Sega Enterprises, Ltd.

Printed in Japan (/)

50630